TM 55-6930-210-10 OPERATOR'S MANUAL FOR AH-1 Q-to-S

217 Pages·2016·0.96 MB·English

TM 55-6930-210-10
Technical Manual
OPERATOR'S MANUAL
FOR
AH-1 Q-to-S (COBRA) FLIGHT WEAPONS SIMULATOR
"Approved for public release; distribution is unlimited."
This copy is a reprint which includes current
pages from Change 1.
HEADQUARTERS, DEPARTMENT OF THE ARMY
7 APRIL 1987
TM 55-6930-210-10
WARNING
HIGH VOLTAGE
is used in the operation of this equipment.
DEATH ON CONTACT
or severe injury may result if personnel fail to observe safety
precautions.
Learn the areas containing high voltage in each piece of equipment.
Under no circumstances should operation of this device be undertaken
when cabinets and/or protective covers are removed or open.
WARNING
Motion system operation requires that
SEAT BELTS BE USED AT ALL TIMES.
In the cases of runaway motion, immediately
activate EMERGENCY STOP switch.
DEATH
or severe injury may result if personnel fail to observe safety
precautions.
WARNING
EMERGENCY STOP
Controls are located at each student station control panel and at each
instructor/operator console. Depressing this switch shuts down the
entire simulator complex.
DEATH
or severe injury may result if personnel fail to observe safety
precautions.
a
TM 55-6930-210-10
WARNING
Sensors that detect heat, lack of airflow, and unsafe mechanical
conditions are provided. UNDER NO CIRCUMSTANCES SHOULD THE FLIGHT
SIMULATOR BE OPERATED WITH A SAFETY WARNING DEVICE BYPASSED.
DEATH
or severe injury may result if personnel fail to observe safety
precautions.
WARNING
FIRE
Should fire develop, activate EMERGENCY STOP
and exit cockpit. DO NOT USE FIRE EXTINGUISHER IN CONFINED COCKPIT.
DEATH
or severe injury may result if personnel fail to observe safety
precautions.
WARNING
BOARDING RAMP
May fail to deploy during a power failure.
Caution should be exercised when exiting simulator.
DEATH
or severe injury may result if personnel fail to observe safety
precautions.
WARNING
Releasing trainer from freeze condition
with incorrect rotor rpm may cause motion surges.
DEATH
or severe injury may result if personnel fail to observe safety
precautions.
b
TM 55-6930-210-10
INSERT LATEST CHANGED PAGES. DESTROY SUPERSEDED PAGES.
LIST OF EFFECTIVE PAGES
NOTE: The portion of the text affected by the changes is indicated
by a vertical line in the outer margins of the page. Changes
to illustrations are indicated by miniature pointing hands.
Changes to wiring diagrams are indicated by change legends.
Dates of issue for original and changed pages are:
Original......0........7 Apr 87
Change......1........31 Aug 1989
TOTAL NUMBER OF PAGES IN THIS PUBLICATION IS 229 CONSISTING OF THE FOLLOWING:
Page *Change Page *Change Page *Change
No. No. No. No. No. No.
a - b............................ 0 7-1 - 7-2.1........................... 1
A - B........................... 1 7-2.2 Blank......................... 1
Record of Changes..... 1 7-3 ..................................... 1
Blank ......................... 0 7-4 - 7-15............................ 0
i - iv............................ 1 7-16 - 7-18.2....................... 1
V ................................ 0 7-19.................................... 1
vi................................ 1 7-20 - 7-21.......................... 0
vii - ix.......................... 0 7-22.................................... 1
x Blank....................... 0 7-23 - 7-28.......................... 0
1-1.............................. 0 7-29.................................... 1
1-2 Blank.................... 0 7-30 - 7-57.......................... 0
2-1 - 2-3...................... 0 7-58.................................... 1
2-4 - 2-4.1................... 1 7-59 - 7-105........................ 0
2-4.2 Blank ................ 1 7-106.................................. 1
2-5.............................. 0 7-107.................................. 0
2-6 - 2-8...................... 1 7-108.................................. 1
2-9 - 2-10.................... 0 7-109 - 7-111...................... 0
2-11 - 2-12.................. 1 7-112 Blank........................ 0
2-13 - 2-21.................. 0 8-1 - 8-25............................ 0
2-22............................ 1 8-26 Blank.......................... 0
3-1 - 3-3...................... 0 9-1 - 9-4.............................. 0
3-4 Blank.................... 0 Glossary 1-
4-1.............................. 1 Glossary 5 ................... 0
4-2 Blank.................... 0 Glossary 6 ......................... 1
5-1 - 5-3...................... 0 Glossary 7.......................... 0
5-4 - 5-5...................... 1 Glossary 8 Blank................ 0
5-6 Blank.................... 0 Index 1............................... 1
6-1.............................. 1 Index 2............................... 0
6-2.............................. 0 Index 3............................... 1
6-3 - 6-4...................... 1 Index 4............................... 0
6-5.............................. 1 Index 5............................... 1
6-6 Blank.................... 0 Index 6 -
Index 8.............................. 1
*Zero in this column indicates an original page.
Change 1 A
TM 55-6930-210-10
RECORD OF CHANGES
CHANGE ENTERED
NO. DATE TITLE OR BRIEF DESCRIPTION BY
1 CRISP ECP (TSU), AVSCOM
NIGHT VISION GOGGLES
(NVG) AND G-METER
CAPABILITY (ECP-7)
CHANGE 1 B
TM 55-6930-210-10
C 1
CHANGE HEADQUARTERS
DEPARTMENT OF THE ARMY
NO. 1 WASHINGTON, D.C., 31 August 1989
OPERATOR'S MANUAL
FOR
AH-1 Q-to-S (COBRA) FLIGHT WEAPONS SIMULATOR
TM 55-6930-210-10, 7 April 1987, is changed as follows:
1. Remove and insert pages as indicated below. New or changed text material is indicated by a vertical bar in
the margin. An illustration change is indicated by a miniature pointing hand.
Remove pages Insert pages
A and B A and B
i through vi i through vi
2-3 and 2-4 2-3 and 2-4
- - - 2-4.1/2-4.2
2-5 through 2-8 2-5 through 2-8
2-11 and 2-12 2-11 and 2-12
2-21 and 2-22 2-21 and 2-22
4-1/4-2 4-1/4-2
5-3 and 5-4 5-3 and 5-4
5-5/5-6 5-5/5-6
6-1 through 6-4 6-1 through 6-4
6-5/6-6 6-5/6-6
7-1 and 7-2 7-1 and 7-2
- - - 7-2.1/7-2.2
7-3 and 7-4 7-3 and 7-4
7-15 through 7-18 7-15 through 7-18
- - - 7-18.1 and 7-18.2
7-19 through 7-22 7-19 through 7-22
7-29 and 7-30 7-29 and 7-30
7-57 and 7-58 7-57 and 7-58
7-105 through 7-108 7-105 through 7-108
Glossary 5 and Glossary 6 Glossary 5 and Glossary 6
Index 1 through Index 8 Index 1 through Index 8
2. Retain this sheet in front of manual for reference purposes.
TM 55-6930-210-10
C 1
By Order of the Secretary of the Army:
CARL E. VUONO
General, United States Army
Official: Chief of Staff
WILLIAM J. MEEHAN II
Brigadier General, United States Army
The Adjutant General
DISTRIBUTION:
To be distributed in accordance with DA Form 12-31, Operator's Maintenance requirements for Flight Simulator, 2B-
3A.
TM 55-6930-210-10
TABLE OF CONTENTS
NOTE
An alphabetical index is located at the back of this manual.
The introduction (Chapter 1) explains the material covered in
each section.
Section/Para Page
SAFETY SUMMARY viii
CHAPTER 1. INTRODUCTION 1-1
1-1. SCOPE 1-1
1-2. GENERAL 1-1
1-2.a. Simulation 1-1
1-2.b. Configuration 1-1
1-3. REPORTING OF ERRORS 1-1
1-4. ABBREVIATIONS 1-1
CHAPTER 2. SYSTEM DESCRIPTION AND OPERATION 2-1
Section I. GENERAL 2-1
2-1. OPERATIONAL SYSTEM 2-1
2-2. SIMULATOR COMPARTMENTS 2-1
2-3. INSTRUCTOR/OPERATOR STATIONS 2-3
2-4. MOTION SYSTEM 2-3
2-5. VISUAL SYSTEM 2-4
2-5.1 TELESCOPIC SIGHT UNIT 2-4
2-6. COMPUTER SYSTEM 2-4.1
Section II. INSTRUCTOR/OPERATOR STATION DESCRIPTION 2-5
2-7. GENERAL DESCRIPTION 2-5
2-8. IOS CONTROL PANELS 2-5
2-9. PILOT/GUNNER CONTROL PANELS 2-5
2-10. INSTRUCTOR SEATS 2-5
2-11. OBSERVER SEATS 2-5
2-12. IOS AREA LIGHTING 2-5
2-13. INSTRUCTOR INTERCOMMUNICATIONS SYSTEM 2-9
2-14. WORK SURFACE 2-9
2-15. TIME REFERENCES 2-9
Section III. MODES OF OPERATION 2-10
2-16. GENERAL 2-10
2-17. TRAINING 2-10
2-17.a. Independent Training 2-10
2-17.b. Integrated Training 2-10
2-18. CHECKRIDE 2-12
2-19. DEMONSTRATION 2-12
2-19.1 TSU MODES 2-12
Section IV. TRAINING CAPABILITIES 2-13
2-20. GENERAL 2-13
2-21. TRAINING OBJECTIVES 2-13
2-21.a. Basic Maneuvers 2-13
Change 1 i
TM 55-6930-210-10
Section/Para Page
2-21.b. Advanced Maneuvers 2-13
2-21.c. Emergency Maneuvers 2-14
2-21.d. Nap--of-the-Earth Maneuvers 2-14
2-21.e. Gunnery Maneuvers 2-14
2-22. SIMULATION SYSTEM CAPABILITIES 2-15
2-22.a. Visual Area Navigation 2-15
2-22.b. Nav/Comm Radio 2-15
2-22.c. Tactical Environment 2-15
2-22.d. Atmospheric Environment 2-15
2-22.e. Motion Cues 2-15
2-22.f. Environmental Sound Cues 2-15
2-22.g. Seat Positions 2-15
2-22.h. Special Capabilities 2-15
2-23. VISUAL SYSTEM CAPABILITIES 2-16
2-24. TRAINING TASKS 2-17
2-24.a. Simulated Aircraft 2-17
2-24.b. Flight Control 2-17
2-24.c. Pilot/Gunner Tasks 2-17
2-24.d. Instructor/Operator Tasks 2-18
2-24.e. Automation of Instructional Function 2-18
2-24.f. Briefing 2-19
2-24.g. Critique 2-19
2-24.h. Cueing 2-19
2-24.i. Feedback 2-20
Section V. SYSTEMS SIMULATED 2-21
2-25. GENERAL 2-21
2-26. ACCESSORY SYSTEMS 2-21
2-27. SOUND SIMULATION 2-21
2-27.a. Aircraft Sounds 2-21
2-27.b. Weapon Sounds 2-21
2-28. MOTION SIMULATION 2-21
2-29. VIBRATION SIMULATION 2-22
2-30. COCKPIT INSTRUMENTATION SIMULATION 2-22
2-31. RADIO COMMUNICATION AND INTERCOMMUNICATION
SYSTEM SIMULATION 2-22
2-32. MALFUNCTION SIMULATION 2-22
2-33. CONTROL LOADING 2-22
2-34. ARMAMENT SYSTEMS 2-22
CHAPTER 3. AVIONICS 3-1
3-1. GENERAL 3-1
3-2. COMMUNICATIONS EQUIPMENT 3-1
3-3. NAVIGATION EQUIPMENT 3-2
3-4. RADAR AND TRANSPONDER EQUIPMENT 3-3
CHAPTER 4. TACTICS 4-1
4-1. GENERAL 4-1
4-2. VISUAL SIMULATION 4-1
4-3. TRAINING 4-1
4-4. EVALUATION 4-1
Change 1 ii
TM 55-6930-210-10
Section/Para Page
CHAPTER 5. OPERATING LIMITS AND RESTRICTIONS 5-1
5-1. GENERAL 5-1
5-2. AVIONICS 5-1
5-3. TEMPERATURE AND HUMIDITY 5-1
5-4. OCCUPANCY 5-1
5-5. MOTION SYSTEM 5-2
5-6. VISUAL SYSTEM 5-2
5-7. AUDIO SYSTEM 5-2
5-8. IOS CRT CONTROLLABLE PARAMETERS 5-2
5-8.a. Environmental Conditions 5-2
5-8.b. Freezable Flight Conditions 5-3
5-8.c. Editable Flight Conditions 5-3
5-8.d. Miscellaneous Conditions 5-3
5-8.e. Malfunctions 5-3
5-9. COCKPIT CIRCUIT BREAKERS 5-3
5-10. ARMAMENT SYSTEM 5-4
5-11. TELESCOPIC SIGHT UNIT TARGETS 5-4
5-12. INDEPENDENT MODE 5-4
5-13. INTEGRATED MODE 5-5
CHAPTER 6. VISUAL SYSTEM 6-1
6-1. GENERAL DESCRIPTION 6-1
6-1.a. Integrated Mode 6-1
6-1.b. Independent Mode 6-1
6-2. CAMERA MODEL SYSTEM 6-1
6-3. MODEL BOARD 6-1
6-4. CULTURAL LIGHTING 6-3
6-4.a. Runway Acquisition Lighting 6-3
6-4.b. Confined Area Lighting 6-3
6-5. FIELD-OF-VIEW (FOV) 6-3
6-5.a. Through-the-Window Displays 6-3
6-5.b. Telescopic Sight Unit 6-4
6-6. WEAPONS EFFECTS 6-4
6-7. VISUAL SYSTEM CAPABILITIES 6-4
6-7.a. Lighting 6-4
6-7.b. Field-of-View 6-4
6-7.c. Landing Areas 6-4
6-7.d. Special Effects 6-4
6-7.e. Weapons Effects 6-5
6-7.f. Altitude Representation 6-5
6-7.g. Focus 6-5
6-7.h. Ambient Light Effect 6-5
6-7.i. Probe Protection 6-5
6-7.j. Visual Transition 6-5
6-7.k. Night Vision Goggles 6-5
Change 1 iii